沼氣生物脫硫前端的預處理技術
Pretreatment technology of biogas biological desulfurization front end
1.當產氣原料為畜禽糞便、餐廚垃圾、垃圾滲濾液等能產生灰塵的沼氣之前，應做沼氣除塵預處理，預處理設備有洗氣塔(濕式)、除塵塔（干式）。
1. Before the raw materials for gas production are livestock manure, kitchen waste, landfill leachate and other biogas that can produce dust, biogas dust removal pretreatment shall be carried out. The pretreatment equipment includes gas washing tower (wet) and dust removal tower (dry).
2.生物脫硫的水源如果是地下水等含鹽量較大時，應對自來水增設軟化水裝置。
2. If the water source for biological desulfurization is groundwater with large salt content, a softened water device shall be added to the tap water.
3.當預處理沼氣中帶有大量的氨氣時，如甲方要求處理時，可在濕式洗氣系統中的循環水中宜放適當?shù)柠}酸或硫酸，酸性循環水可以吸收氨氣，當洗氣系的循環水接近飽和時，應及時排掉，換循環水。
3. When there is a large amount of ammonia in the pretreated biogas, if Party A requires treatment, appropriate hydrochloric acid or sulfuric acid can be put into the circulating water in the wet gas washing system, and the acidic circulating water can absorb ammonia. When the circulating water of the gas washing system is close to saturation, it should be discharged in time and replaced with circulating water.
4.當預處理沼氣溫度在40度以上時，沼氣在生物脫硫前，應做降溫處理。降溫下降到35度以下為宜。
4. When the temperature of pretreated biogas is above 40 ℃, the biogas shall be cooled before biological desulfurization. The temperature should drop below 35 degrees.
5.當預處理沼氣的壓力小于3Kpa時，沼氣在生物脫硫之前，應對沼氣進行增壓，增壓到3kpa以上。
5. When the pressure of pretreated biogas is less than 3kpa, the biogas shall be pressurized to more than 3kpa before biological desulfurization.
The wonderful contents of this article are provided by the knowledge of biogas desulfurization. There are many wonderful contents on this website. You can click to enter more contents: http://www.cdbsj.com We have special customer service to answer your questions
魯公網安備37011202000764號號 網站地圖XMLTXT
企業二維碼
2022-05-26
